Building Maintenance Technician

The Building Maintenance Technician (BMT) is part of the Vanderbilt University Maintenance and Operations (VUMO and is a key individual responsible for the ongoing maintenance and repair of a building or area. Building Maintenance Technicians need to have a good knowledge of building skills, including HVAC, plumbing, drywall installation, painting, and general building repair. The position reports directly to a Zone Manager.

WORKING HOURS: 7:30 am to 4:00 pm - Monday - Friday;work additional hours as needed

Duties and Responsibilities:

• Change filter in dorm room unit
• Check chilled water pressure in building
• Check Steam pressure at PRV station in building
• Check run status on air handling unit
• Check alarm on VFD
• Investigate water leaks
• Change air filters in AHU
• Grease pump/motor bearings
• Check a steam trap for proper operation
• Check/prime AC drain trap
• Assist HAR Tech in pulling motors on equipment
• Assist Tech with condensate pump system repairs
• Clean AHU coils/air intakes
• Change out thermostats
• Check discharge air temps on HVAC equipment
• Clean and organize work areas, including mechanical/electrical rooms' parts storage areas
• Plunge sink and toilet (snaking)
• Replace shower curtain rods
• Tighten toilet seat
• Replace wax ring on toilet and reset toilet
• Rebuild flush valve
• Use small sewer machine
• Change batteries in auto flush valves
• Use pro-press to install piping and valves
• Change out fire extinguishers (including record keeping)
• Test fire extinguishers (including record keeping)
• Clean out drains
• Caulk sinks and vanities
• Change out toilet tank float/flush assemblies
• Change out water stop valves
• Help w/winterization at Stadium
• Help w/installation of shutoff valves on water mains to each floor of buildings
• Help plumber w/various plumbing/piping repairs
• Assist plumber w/repair or replacement of water heaters
• Minor piping repairs to fix leaks
• Replace ceiling tile
• Replace rubber base
• Replace carpet and carpet squares
• Hang pictures/bulletin/dry erase/chalk boards
• Cut and install small drywall pieces/mud
• Patch holes and nail holes
• Help carpenter lay ceramic floor tile and grout
• Respond to roof leak calls and locate leak
• Change out/install door sweeps
• Install/replace door stops
• Repair tracks on sliding doors
• Minor dorm furniture repairs
• Assist carpenter w/assembling trash cans/benches & setting them
• Repair brackets for wall shelving
• Replace lamps and ballasts in any fixture
• Replace/upgrade fixtures
• Replace receptacles and switches
• Reset small amperage circuit breakers
• Proper handling/disposal of lamps and ballasts
• Organize bulb supply and spent bulb storage locations
• Use Volt-Ohm Meter to check voltage/current
• If trained, use man lift/boom lift/scissor lift and single man lift/bucket truck for various repairs
• String lights and drop cords in tents for special events
• Assemble scaffolding/adjustable ladders to work on various lighting repairs
• Assist electrician on conduit runs/wire pulls
• Hand banners on street light poles
• Set up and monitor personal work order query
• Process daily work order time sheet
• Operate vehicle/golf cart and perform operator level maintenance
• Other duties related to classification

Qualifications:

• Applicant should have a High School education or equivalent.
• Requires regular physical effort; must be able to lift 30 pounds, bending, climbing, and a variety of physical activities.
• Ability to effectively communicate and follow written and oral instructions.
• Ability to: change light bulbs, ballasts, fixtures, switches/plates, HVAC filters, thermostats, hang pictures, tighten screws on hardware, lubricate hinges and closures.
• Touch up paint as needed.
• Simple plumbing repairs.
• Perform preventive maintenance on equipment.
• Valid Driver License is required; must have and maintain a valid driver's license and a satisfactory driving record. Vanderbilt University engages a third party to provide up-to-date notifications regarding negative changes to motor vehicle records